If catalyst is defective, then when it is removed, the car engine regains its original, factory parameters, it begins to “breathe” more easily, resulting in reduced fuel consumption and increased power. In cases where the catalyst is removed in order to modernize the exhaust system, this procedure is usually supplemented by installation of a new exhaust pipe type silencer, which creates significantly less obstacles to exhaust gases than the catalyst.
In combination with reflashing of a power unit (which is also performed), this leads to an increase in power of a power unit. It should be noted that this method of tuning is often called “amateur”, because when tuning the exhaust system performed by professionals (used, for example, to “refine” sports cars), a lot of calculations are made and a large number of parameters are involved. Professional tuning is done only by highly qualified specialists and costs considerable amounts.
converter unlimited Removal
The removal of catalyst is most often a necessary measure, but sometimes the catalyst is removed in order to finalize the exhaust system. A faulty catalyst creates a lot of unpleasant problems in the form of errors that light up on a panel, as well as a significant deterioration in dynamic readings of a car. The state of catalyst and correctness of its operation are monitored by the so-called lambda or oxygen sensor.
The sensor monitors the consistency of exhaust, if the catalyst is not working, composition of exhaust changes, to which lambda immediately reacts and reports a corresponding error.
Repair of catalytic converter is not possible, in case of failure, it is necessary to completely remove defective catalyst, and install a new one in its place. The catalyst is removed for a reason that the cost of a new one is quite high, so most often in the event of a malfunction, a flame arrester is installed in its place.
Removal of catalyst cannot but be invisible; many describe it in different ways. Some say that it felt like there was a trailer or an anchor from which they got rid. Others say that the car had a second wind, but they all have one thing in common : significant improvement in dynamic performance.
The removal of catalyst is an extreme measure, which is undesirable if the engine works as it should. In addition, if financial ability allows you to perform a full replacement of catalyst with a new one, then it is better to do just that, in which case you will not have to interfere with exhaust system, as well as brains of your car.
It will not require any tricks and other “lotions”, which can not be avoided when removing the catalyst.